Product brief introduce 產品簡介

      This product is a high-performance ether polycarboxylic acid mother liquor with special functions and a wide range of applications,

It has the characteristics of low dosage, high water reduction rate, high reinforcement, high durability, anti-bleeding, anti-segregation, low air content, good compactness and cohesion, good concrete workability, strong compounding adaptability, and (green) environmental protection.

The product changes the anchor group type of the main chain and the structure and length of the side chain，Adjust its adsorption behavior on the surface of cement particles and the rheological behavior of cement paste，to meet the requirements of various performance concrete projects.

    聚羧酸高性能減水劑母液（超塑化劑）是一款具有特殊功能、適用范圍廣泛的醚類聚羧酸高性能母液，具有摻量低、減水率高、高增強、高耐久、抗泌水、抗離析、含氣量低、密實粘聚性好、混凝土和易性好、復配適應性強、綠色環保等特點。產品通過改變主鏈的錨固基團種類及側鏈結構和長度，調整其在水泥顆粒表面的吸附行為和水泥漿體的流變行為，進而滿足配制各種性能要求的混凝土工程。

Scope of application 適用范圍

      Widely adapted to Portland cement, ordinary Portland cement, slag Portland cement, fly ash cement, pozzolan cement, etc., various admixtures of different specifications and models of cement, slag, fly ash, machine-made sand, mountain sand, river sand, etc. It can be used in various industrial and civil constructions, highways and railways, municipal bridges, water conservancy ports and other projects after being compounded according to the needs of use. It is especially suitable for economical commodities Concrete.
      廣泛適應硅酸鹽水泥、普通硅酸鹽水泥、礦渣硅酸鹽水泥、粉煤灰水泥、火山灰水泥等不同規格型號的水泥及礦渣、粉煤灰、機制砂、山砂、河砂等各種摻合料，可根據使用需要復配后用于各種工業及民用建筑、公路鐵路、市政橋梁、水利港口等工程中的預拌和現澆混凝土、鋼筋混凝土、預應力筋鋼筋混凝土，特別適用于經濟型商品混凝土。

Main performance 主要性能

Compressive strength ratio  使用注意事項

1. The recommended dosage of this product is 0.3% to 0.8% of the total weight of the cementitious material. Non-end-use products, a trial mix test should be carried out before use to find the best dosage.
  本產品推薦摻量為膠凝材料總重量的0.3%～0.8%，非終端使用產品，使用前應進行試配試驗，以求最佳摻量。

2. As a masterbatch, this product can be combined with other types of carboxylic acids, defoamers, air-entraining agents, retarders, etc. to form admixtures to meet the requirements of different project categories, construction techniques and temperature conditions.

  本產品作為母料，可以和其他類型羧酸、消泡劑、引氣劑、緩凝劑等復配成外加劑，滿足不同工程類別、施工工藝、施工技術和氣溫條件要求。

3. Due to the differences in adaptability between different specifications and models of cement, mixtures and additives, the adaptation test should be done before use.

  由于不同規格型號水泥和摻合料與外加劑之間存在適應性差異，因此使用前應做好適配試驗。

4. It can be added to the mixing water during use, or added to the concrete mixer at the same time as the mixing water. The mixing time is not less than 120s. The concrete mixing test should be carried out to confirm the quality of the concrete before use.

  使用時可加入到拌合水中，或與拌合水同時加入混凝土攪拌機中，攪拌時間不少于120s，使用前應進行混凝土拌合試驗確認混凝土質量。

5. When using this product, it must be accurately measured and stirred evenly. Excessive addition of additives or uneven mixing may cause segregation of bleeding and difficulty in pumping.

  使用本產品時，必須計量準確，攪拌均勻。加入超量外加劑或攪拌不均勻可能導致離析泌水、泵送困難等現象。

6. Since the product has the characteristics of high water reducing rate, a higher sensitivity to slump of water must be strictly controlled use of water

  由于本產品具有高減水率的特點，因此坍落度對用水量的敏感性較高，使用時必須嚴格控制用水量。

7. This product is non-toxic and harmless, biodegradable, but not edible. If it gets into the eyes, it should be rinsed with water in time. If you cause allergies to part of the human body, you should consult a doctor in time.

  本品無毒無害，可生物降解，但不可食用，誤入眼睛時應及時用清水沖洗。對部分人體造成過敏現象應及時就醫。

五、Packaging and storage 包裝與貯存

1. This product is liquid and is packed in 1000kg plastic drums or plastic bags.
   本產品為液劑，采用1000kg塑料桶裝或塑料袋包裝。

2. Should be placed in a cool, dry place, sealed storage away from direct sunlight, rain or negative temperature environment preservation.
   應置于陰涼、干燥處密封儲存，避免陽光直射、雨淋或負溫環境保存。


3. The warranty period is one year, and the overdue products can only be used after being tested and verified.
   質保期一年，超期產品經試驗驗證合格后方可繼續使用。

六、Technical Support  技術支持

   In the preparation of various types of concrete, we provide free professional technical consulting services and provide users with formula system optimization services.

  本產品在各類混凝土配制中，公司免費提供專業技術咨詢服務、提供各用戶配方體系優化服務。